After the sudden brake failure of the mine loader, some novice companies have the opportunity to show panic, but it is not good for dealing with this kind of failure. Therefore, whenever you encounter this kind of situation, you must deal with it calmly and calmly. If you can't deal with it yourself, you should seek help in time.

小編為大家講一下，盡可能利用地形等可利用的條件來減速，將車輛駕駛到平坦的地方，立即停車處理。

Xiaobian will tell you that we should use the available conditions such as terrain to slow down as much as possible, drive the vehicle to a flat place and stop it immediately.

如果礦井裝載機在上坡的時候出現剎車失靈，應該適當掛入低速擋，保持足夠的動力駛上坡頂停車。如需要半坡停車，應該保持前進低擋位，拉緊手制動，如果有后滑的現象，車尾應該朝向煤壁、巖壁的一面，并打開大燈以及緊急信號燈，這樣做的目的就是引起后方車輛的注意。

If the brake of the mine loader fails when going uphill, it should be properly put into the low gear to maintain sufficient power to drive up the slope top and stop. If you need to stop on a half slope, you should keep the forward low gear and tighten the hand brake. If there is a backward slip, the rear of the car should face the coal wall and rock wall, and turn on the headlights and emergency signal lights. The purpose of this is to attract the attention of the vehicles behind.

下坡剎車失靈的話，不能利用車輛本身的機構來控制車速，或找不到合適的物體降低車速的時候，駕駛員應該果斷地利用車廂一側等鋼性部位，向無電纜、水管一側煤壁或巖壁靠攏，以摩擦、碰撞來增加阻力，達到強行停車脫險的目的，更大可能地減少事故的損失。

If the downhill brake fails, the vehicle's own mechanism cannot be used to control the speed, or when a suitable object cannot be found to reduce the speed, the driver should decisively use the rigid parts such as one side of the carriage to approach the coal wall or rock wall on the side without cables and water pipes, so as to increase the resistance by friction and collision, so as to achieve the purpose of forced parking and escape, and reduce the loss of accidents more likely.

提高礦井裝載機的管理，嚴格要求司機按照操作規程、輔助運輸管理的辦法來操作執行。

Improve the management of mine loaders and strictly require drivers to operate in accordance with the operating procedures and auxiliary transportation management methods.

加強運輸教育培訓，認真學習事故案例，吸取事故教訓，總結事故處理經驗。

Strengthen transportation education and training, carefully study accident cases, learn accident lessons and summarize accident handling experience.

在運行過程中進行預見性剎車，駕駛員在車輛上下坡前，不管有沒有情況都應該踩一下剎車，這樣既可以檢驗剎車性能，也可以在發現剎車失靈時贏得控制車速的時間。

Conduct predictive braking during operation. The driver should step on the brake before the vehicle goes up and down the slope, whether there is any situation or not. This can not only test the braking performance, but also win the time to control the speed when the brake fails.

在下坡路段運行時，要用低速檔行走。

When running on downhill sections, use low gear.

礦井裝載機駕駛員要按時對車輛的剎車系統進行保養，防止車輛因缺少剎車油、油管老化、剎車片磨損嚴重等情況導致剎車失靈。

The driver of the mine loader shall maintain the vehicle's braking system on time to prevent the vehicle from braking failure due to lack of brake oil, aging oil pipe, serious wear of brake pads, etc.

以上就是為大家介紹的有關礦井裝載機的詳細介紹,希望對您有所幫助.如果您有什么疑問的話,歡迎聯系我們.我們將以的態度,為您提供服務http://yygsbaby.com

The above is the detailed introduction of mine loader, which I hope will be helpful to you If you have any questions, please contact us We will provide you with professional service http://yygsbaby.com