Loader is a kind of earthwork construction machinery which is widely used in highway, railway, construction, hydropower, port, mine and other construction projects. It is mainly used for shoveling soil, sand, lime, coal and other bulk materials. It can also be used for light shoveling of ore and hard soil. The mine loader is used in the mine. In order to prevent the brake failure of the mine loader, causing personal injury and equipment damage, the following is the regulations that the driver of the mine loader should abide by.

礦井裝載機駕駛員面對車輛剎車忽然失靈，要沉著冷靜的進行處理，盡可能利用地形等可利用條件進行減速，將車輛駕駛到平坦處立即停車處理。

In the face of the sudden failure of the vehicle brake, the driver of the mine loader should deal with it calmly, use the terrain and other available conditions to decelerate as much as possible, drive the vehicle to a flat place and stop immediately.

礦井裝載機上坡時出現剎車失靈，應適時減入低速擋，保持足夠的動力駛上坡頂停車。如需半坡停車，應保持前進低擋位，拉緊手制動，如有后滑現象，車尾應朝向煤壁、巖壁或安 全一面，并打開大燈和緊急信號燈，引起后方車輛的注意。

In case of brake failure when the mine loader ascends the slope, it is necessary to reduce to low gear in time to keep enough power to drive up the slope and stop. If you need to stop at half slope, you should keep the forward low gear, tighten the hand brake, if there is a back slip phenomenon, the rear of the car should face the coal wall, rock wall or safety side, and turn on the headlights and emergency signal lights to attract the attention of the rear vehicles.

下坡剎車失靈，不能利用車輛本身的機構控制車速，或找不到合適的物體降低車速時，駕駛員應果斷地利用車廂一側等鋼性部位，向無電纜、水管一側煤壁或巖壁靠攏，以摩擦、碰撞來增加阻力，達到強行停車脫險的目的，盡可能地減少事故損失。

When the downhill brake fails, and the vehicle can't control the speed by its own mechanism, or can't find a suitable object to reduce the speed, the driver should decisively use the steel parts such as one side of the car to get close to the coal wall or rock wall without cable or water pipe, and increase the resistance by friction and collision, so as to achieve the purpose of forced parking and escape, and reduce the accident loss as much as possible.

提高礦井裝載機的管理，嚴格要求司機按照操作規程、輔助運輸管理辦法操作執行。

Improve the management of mine loader, strictly require the driver to operate in accordance with the operating procedures and auxiliary transportation management methods.

嚴禁礦用裝載機超 速行駛。

It is strictly forbidden for the mine loader to drive over the speed limit.

加強運輸安 全教育培訓，認真學習事故案例，吸取事故教訓，總結經驗。

Strengthen transportation safety education and training, seriously study accident cases, draw lessons from accidents and sum up experience.

在運行過程中進行預見性剎車，駕駛員在車輛上下坡前不管有無情況都應該踩一下剎車。既可以檢驗剎車性能，也可以在發現剎車失靈時贏得控制車速的時間。

In the process of running, the driver should step on the brake before going up and down the slope regardless of the situation. It can not only test the brake performance, but also gain the time to control the speed when the brake fails.

在下坡路段運行時，要用低速檔行走。

When running in downhill section, use low gear.

礦井裝載機駕駛員要按時對車輛的剎車系統進行保養，防止車輛因缺少剎車油、油管老化、剎車片磨損嚴重等情況導致剎車失靈。、

The driver of the mine loader should maintain the brake system of the vehicle on time to prevent the brake failure caused by the lack of brake oil, aging of oil pipe and serious wear of brake pad

以上就是小編為大家介紹的關于礦井裝載機的相關內容，希望可以幫助您。更多精彩內容可以直接關注：http://yygsbaby.com

The above is a small series for you to introduce the relevant content of the mine loader, hope to help you. More highlights can be directly focused on: http://yygsbaby.com