In the main operating system of underground loader, the transmission performance of hydraulic and hydraulic system directly affects the quality and efficiency of engineering construction. Therefore, understanding and mastering its use and maintenance knowledge and troubleshooting technology is an important content for modern engineers and technicians.

關乎井下裝載機變矩器的保養方法我們?yōu)槟偨Y(jié)以下幾點：

As for the maintenance methods of torque converter of underground loader, we summarize the following points for you:

①每班工作后，應檢查井下裝載機變速箱有關機件的結合緊固情況，如有松動，應及時擰緊。

① After each shift, check the binding and fastening of relevant parts of the gearbox of the underground loader. If it is loose, tighten it in time.

②每工作100h后，擰下變矩器蓋上的加油螺帽，用油位尺檢查油面高度，油面高度應在油位尺上下刻線之間。測量時，拖拉機應處于水平位置。油量不足時應及時添加。

② After every 100h of operation, unscrew the oil filling nut on the torque converter cover, and check the oil level with the oil level gauge, which shall be between the upper and lower scribed lines of the oil level gauge. When measuring, the tractor should be in a horizontal position. When the oil quantity is insufficient, it shall be added in time.

③的潤滑油為齒輪油，要注意保持齒輪油的清潔，油中不應有機械雜質，否則會加速齒輪的磨損。加油時，應注意加油工具和加油口的清潔。

③ The lubricating oil is gear oil. Pay attention to keep the gear oil clean. There should be no mechanical impurities in the oil, otherwise it will accelerate the wear of the gear. When refueling, pay attention to the cleanliness of refueling tools and refueling ports.

④井下裝載機每工作500h左右應清洗變速箱，更換齒輪油。清洗方法如下：井下裝載機工作結束后趁熱放出贓油，然后加入適量的清潔柴油，拖拉機前進、倒退數次，然后放出柴油，再加入清潔齒輪油。注意不同季節應選用不同規格的齒輪油，冬季用冬季齒輪油，夏季用夏季齒輪油。

④ The gearbox shall be cleaned and the gear oil shall be replaced every 500h of underground loader. The cleaning method is as follows: after the work of the underground loader is completed, release the stolen oil while it is hot, then add an appropriate amount of clean diesel, advance and reverse the tractor several times, then release the diesel, and then add clean gear oil. Note that different specifications of gear oil shall be selected in different seasons. Winter gear oil shall be used in winter and summer gear oil shall be used in summer.

除此之外定期檢查各處油封和襯墊紙板的密封、完好情況，必要時應予更換。更換時，襯墊紙板的厚度應與原來厚度相同以保證正確的軸向間隙，保證井下裝載機的正常運行。

In addition, regularly check the sealing and integrity of all oil seals and liner paperboards, and replace them if necessary. During replacement, the thickness of liner paperboard shall be the same as the original thickness to ensure correct axial clearance and normal operation of underground loader.